BMW Forums : BimmerForums banner

actuator

  1. General BMW Discussions
    Hi so I’ve had a reconditioned turbo put into my 2015 1 series after the old one cracking and since I had the new turbo put in the car is in limp mode and has a drive train warning light on the I drive. When plugged in the errors are “cold start not learned” and wastegate not closing error. My...
  2. Auto Electrical Forum
    I have a BMW 318D M47 engine. 224,000 miles, brand new turbo. The first issue I'm having is the turbo is boosting at idle. You can hear it spooling up, on my phone it says it's boosting at 0.8psi. It doesn't always do it. Most of the time it's reading a vacuum of 0.7 2nd issue you can really...
  3. General BMW Discussions
    I have a e88 1 series my driver door has stopped opening via central locking the door actuator makes all the right noises but plunger won’t move up or down, I plugged it into my passenger side and it works perfect, this has me baffled any ideas anyone, I’m thinking wiring, but could it be the...
  4. BMW 3 Series Forum - Technical Talk on the BMW E46
    So Im looking to replace my turbo on e46 330cd (convertible) e46 2005 204bhp. Now I am getting conflicting information. Majority of places under the above information and registeration are saying its a garrett turbo with vacuum actuator. However, my current turbo is a garrett with electronic...
  5. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi Guys, My 325d EGR actuator pump is starting to quack and I was going to remap my car with EGR off. if I get a EGR remap I think I can remove the actuator pump. Do I just remove the egr actuator and block off the pipe. Also if im removing the pump would not connecting its electrical connector...
  6. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi all, I have replaced my turbo as the old one has a sticky vanes and then stuck and caused the turbo to blow. With the new reconditioned one installed, everything works fine, I used the car for around 120miles, start and stop, no problem. But this morning when I unlock the car I can hear...
  7. BMW 3 Series Forum - Technical Talk on the BMW E46
    BMW 330cd E46 2005 Turbo actuator problem I believe. Do the symptoms sound right for this, loss of power, most of the time absolutely no power at all. Sometimes I get the full power come through. Also, turbo whistle noise, ie the wastgate noise has stopped as well. Am I right in saying these...
  8. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi all, I am a newbie, need some advice please. I am looking for a replacement actuator for my 2007 320d M47. It comes with the Turbo with serial number 7795498 k/10. The actuator keep clicking when the car is off, and I have lost all power now. The Turbo is not kicking in. Is the...
  9. BMW 5 Series - Tech Talk For All Gen Of 5 Series
    Hello everyone. Ihave a diagnostics as follows: 003f57 charge air pressure controller 004242 glow plug cylinder 4 004587 heated fuel filter 009c77 auxiliary water pump 00a46d did malfunction due to peripheral The car starts great and there is runs well but time to time the top end...
  10. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    All, Have a possible issue with the actuator on my turbo. It's a garrett unit. Seems like it's intermittent as sometimes the car boosts and at other times I get limp mode when planning the right foot. My bmw indy says I should try and get hold of a replacement. Having read other posts...
  11. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi. I wonder if someone could help me please? I have an E91 330d on a '57' plate. I've taken the car to my local garage as there was a noticeable lack of power. The garage have advised me that the turbo actuator is faulty and needs replacing. They have asked me to source a new or refurbished...
  12. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi there! Long time since i last posted on the forum. The car was going in limp mode for a few days since 2009, but i used to get no fault codes with INPA. I thought it was regeneration of the DPF and this and that till i got used to it. The cars has currently 256.500KM on the dash but i...
  13. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hello guys I have just been under my car a sI have noticed a problem with the turbo acuator. When engine starts actuator opens but doesnt close. It stays open until I shut engine off. When i rev it it slightly moves a tad bit. The actuator box what ever its called is leaking oil. I have also...
  14. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi all, having a problem with my 2009 E90 Lci 320d Msport N47 engine mileage 150,000 miles So last week I noticed after I start engine first thing in the morning and start to drive it after about a minute or so the car will go into limp mode won’t rev past 1500rpm, this will last for a minute...
  15. BMW 3 Series Forum - Technical Talk on the BMW E46
    Hi, I've recently been having trouble with some kind of actuator leaking, it has a vacuum hose going to it and a rod connected to some rad flaps.... it's leaking from where the rod comes out. Not sure what the part is called though? Any help would be great. Bmw e46 320d.
  16. BMW 5 Series - Tech Talk For All Gen Of 5 Series
    New turbo installed today to try and alleviate my lack of boost. still coming up with "3F57 CHARGE AIR PRESSURE CONTROLLER and 3F77 BOOST PRESSURE ACTUATOR SIGNAL IMPROBABLE" the turbo came with a recon actuator and i can get it to move. but it just stops working almost immediately. I have...
  17. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    I originally posted this with my introduction, but I think it will probably get more feedback here. I've got an 2011 320d effdyn with an intermittent engine light and power loss. I've done a fair bit of googlefu and I think it's pointing towards my turbo actuator. I've got 6 codes on the...
  18. Turbocharging your BMW
    Hey everyone, im Alex from germany and driving an e46 330d euro4. I want to know if it is possible to change my ectronic turbo actuator to vacuum, like the euro3 330d has. Thank you. Gesendet von meinem A0001 mit Tapatalk
  19. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi again guys, I have another issue. The car has been funding great for the last month until yesterday:-( I started to notice some turbo lag, not every time I accelerate just every now and again. This progressively became more frequent and eventually no boost at all. Got so bad that it wouldn’t...
  20. BMW 3 Series - Tech Talk For All Gen Of 3 Series
    Hi folks, I would be very grateful if you could give me some help with my E91 Just before Christmas I lost boost on my 320d (N47) and have only just been able to get around to taking a look at it. I pulled the following codes from DIS: 4A79 4A74 449A 452A 41A2 I ran the actuator test and...
Top